AirSeal® Single Horizontal Recirculatory Air/Cooler/Freezer Door with Fabric Roll-Up Door
AirSeal doors from Enviro auto-adjust to temperature and humidity changes to maximize your energy efficiency and minimize your refrigeration loss.
- AirSeal’s invisible barrier allows for unobstructed traffic flow with minimal loss of refrigeration and/or heat gain.
- Significantly reduces fog, ice and moisture associated with wide-open doorways.
- Adjustable and programmable air speed controls, allowing for precise application settings.
- Integrated self-regulating EPLC controlled heater unit for optimal air mixing temperature control and condensation reduction.
- AirSeal’s efficiency reduces coil defrosting burden and improves refrigeration cycle efficiency.
- Eliminates maintenance costs associated with hard panel doors.No need for energy absorbing infrared heat lamps.
- Electric or hot gas heat reclaim allows for precise application requirements.
- Reduction of ice, fog and moisture dramatically increases safety and material handling.
- Integral high-speed fabric roll-up door provides high seal efficiency.
- Fully programmable logic controller with preset modes for maximum energy cost savings.
- Two modes of operation:Air shield onlyCombination air-fabric controlImpactable breakaway fabric roll-up door design eliminates costly down time and repair.
- All galvanized or stainless steel design for cleanability.
- Maximum:10’0” x 15’0”.
- Minimum: 6’0” x 6’0”.
(Other sizes available - Consult factoy)
- Galvanized metal.
- Fabric door:
Two-ply PVC impregnated polyester woven fabric.
Integral panel stiffeners.
- NEMA-4 fiberglass control box.
- Fully programmable EPLC controls.
- Variable frequency drive.
- Optimization Controls (Freezer door).
- AirSeal:4,600 cfm at 4” of water gauge.
- Fabric Door:
Two speed operation:
Open at 42"/sec.
Close at 21"/sec.
- Electric activated instant reversing edge.
- Pull cord actuator.
- Remote mount push buttons.
- Photoeye actuator.
- Radio control actuator: single or multiple channel transmitter.
- Loop detector system actuator.
- Motion detector.
- Time delay close.
- Pre-announce to close kit (light/alarm/or combo).
- Fabric door - barrel & operator shroud.
- Vision panel - 28" high across full width of panel.
- White fabric panel.
- Emergency manual release on non-operator side of door.
- Digital display on cooler door.
- Interlock to existing door.
- Stainless steel construction.
- One year limited warranty on all components.
- AirSeal:High efficiency low noise multi-belt driven operator with minimum 5 h.p. motor.
- Fabric Door:In-line, high efficiency 3/4 h.p. electrical motor.